Welcome, Guest

Author Topic: Cleaning plastic foundation  (Read 517 times)

Offline Wits End

  • House Bee
  • **
  • Posts: 101
  • Gender: Male
Cleaning plastic foundation
« on: January 04, 2017, 03:54:06 PM »
Anyone know good ways to clean pierco plastic foundation for rewaxing? Tried scraping, brushing then almost boiling water. Foundation came clean but warped pretty bad.


Sent from my iPad using Tapatalk
Jeff and Kellie Houston
Wits End Blueberry and Bee Farm
Greenwood Mississippi

Offline sawdstmakr

  • Galactic Bee
  • ******
  • Posts: 6727
  • Gender: Male
Re: Cleaning plastic foundation
« Reply #1 on: January 04, 2017, 09:59:36 PM »
I use 2 techniques.
If I have a lot of time before I need them, I stack them outside and let nature clean them up then use a wire brush and a fox tail to remove the remaining dust.
If I need them right away, I will place them in a large pan and use a pressure washer to clean them. It is messy and you are going to get wet but it works real well.

I do not like to wax them until it is close to the time that I need them because our weather is so warm that the bugs get back into them.
When they need to be waxed, I use a 5" firm roller dipped in wax at 170 degrees and roll both sides. This goes very fast.
Jim
"If you don't read the newspaper you are uninformed.  If you do read the newspaper you are misinformed."--Mark Twain

Offline Wits End

  • House Bee
  • **
  • Posts: 101
  • Gender: Male
Re: Cleaning plastic foundation
« Reply #2 on: January 05, 2017, 08:29:08 AM »
Thanks Jim. I have noticed the boxes of frames I have stored in the barn for a couple years were dryer and much easier to clean.


Sent from my iPad using Tapatalk
Jeff and Kellie Houston
Wits End Blueberry and Bee Farm
Greenwood Mississippi

Offline Jim 134

  • Super Bee
  • *****
  • Posts: 2696
  • Gender: Male
    • Franklin County Beekeepers Association
Re: Cleaning plastic foundation
« Reply #3 on: March 12, 2017, 01:44:28 PM »
Hot water Pressure washer. You do not want to get the plastic over a 150F. The plastic will catch a memory ..and Warp.. after you're done cleaning rewax Foundation.

                   BEE HAPPY Jim 134 :smile:

"Tell me and I'll forget,show me and I may  remember,involve me and I'll understand"
        Chinese Proverb

"The farmer is the only man in our economy who buys everything at retail, sells everything at wholesale, and pays the freight both ways."
 John F. Kennedy
Franklin County Beekeepers Association MA. http://www.franklinmabeekeepers.org/

Offline Michael Bush

  • Universal Bee
  • *******
  • Posts: 16106
  • Gender: Male
    • bushfarms.com
Re: Cleaning plastic foundation
« Reply #4 on: March 13, 2017, 12:01:07 PM »
I just put it back in a strong hive...
My website:  bushfarms.com/bees.htm en espanol: bushfarms.com/es_bees.htm  auf deutsche: bushfarms.com/de_bees.htm
My book:  ThePracticalBeekeeper.com
-------------------
"Everything works if you let it."--James "Big Boy" Medlin

Offline Jim 134

  • Super Bee
  • *****
  • Posts: 2696
  • Gender: Male
    • Franklin County Beekeepers Association
Re: Cleaning plastic foundation
« Reply #5 on: March 13, 2017, 01:25:26 PM »
It's been my personal experience. If you do not rewax the plastic foundation. Most of time the bees with put Burr comb in between two frames or up against the outer walls. I hope your experience is different. If you try this without rewaxing the plastic foundation.


       BEE HAPPY Jim 134  :smile:
"Tell me and I'll forget,show me and I may  remember,involve me and I'll understand"
        Chinese Proverb

"The farmer is the only man in our economy who buys everything at retail, sells everything at wholesale, and pays the freight both ways."
 John F. Kennedy
Franklin County Beekeepers Association MA. http://www.franklinmabeekeepers.org/